Hunting Washington Forum

Equipment & Gear => Power Equipment & RV => Topic started by: pendoreilleadventures on November 16, 2013, 05:40:29 PM

Title: Any Jeep Liberty owners out there have a 4x4 issue?
Post by: pendoreilleadventures on November 16, 2013, 05:40:29 PM: Hey I have a 2005 jeep liberty that has a 4x4 issue. The 4x4 engages but is clunking . I was the second owner and bought it from an elderly couple who just used it in town. I have maybe 3000 miles of winter 4x4 uses and maybe 200 miles muddy road uses never pushed it much. worked fine one winter didn't use it again until the following winter and now it quit working.

the 4x4 engages in both 4 hi and 4 lo but kinda of lurges I checked u-joints they are all rock solid. any ideas?

I think the transfer case is a np231 I know that was ran in alot of jeeps can I use one from an older vehicle if this one is toast?
Title: Re: Any Jeep Liberty owners out there have a 4x4 issue?
Post by: huntnphool on November 16, 2013, 05:46:48 PM: Send Jackelope a PM. ;)
Title: Re: Any Jeep Liberty owners out there have a 4x4 issue?
Post by: jeepasaurusrex on November 17, 2013, 08:42:36 AM: Most of the time, a poor shifting T-case is due to it not being used. Keep cycling it and it will eventually free up.
Title: Re: Any Jeep Liberty owners out there have a 4x4 issue?
Post by: jackelope on November 17, 2013, 08:51:09 AM: When does it clunk or lurch?
Title: Re: Any Jeep Liberty owners out there have a 4x4 issue?
Post by: pendoreilleadventures on November 17, 2013, 10:15:00 AM: The whole time its in 4x4

Sent from my C6750 using Tapatalk
Title: Any Jeep Liberty owners out there have a 4x4 issue?
Post by: jackelope on November 17, 2013, 02:43:35 PM: Drain the fluid and see what comes out. That's step 1.
Title: Re: Any Jeep Liberty owners out there have a 4x4 issue?
Post by: BOWHUNTER45 on November 17, 2013, 02:50:58 PM: Had ours since 04 ...never a problem with anything ... sure its something minor :tup:
Title: Re: Any Jeep Liberty owners out there have a 4x4 issue?
Post by: jackelope on November 17, 2013, 03:26:15 PM: After 10+ years of servicing Jeeps I can tell you it's nothing common.